Wstęp
This manual provides essential information for the safe and proper installation, operation, and maintenance of your Leviton Commercial Grade Single Receptacle Outlet, Model 5821-W. This 20 Amp, 250 Volt, NEMA 6-20R, 2-Pole, 3-Wire receptacle is designed for commercial and institutional applications, offering durability and reliable performance. Please read all instructions carefully before beginning installation.
Ważne informacje dotyczące bezpieczeństwa
OSTRZEŻENIE: Ryzyko porażenia prądem elektrycznym lub pożaru.
- Przed instalacją lub serwisowaniem urządzenia należy zawsze wyłączyć zasilanie za pomocą wyłącznika automatycznego lub skrzynki bezpiecznikowej.
- Instalację musi wykonać wykwalifikowany elektryk, zgodnie ze wszystkimi krajowymi i lokalnymi przepisami elektrycznymi.
- Use only copper or copper-clad wire. Do not use with aluminum wiring.
- Upewnij się, że wszystkie połączenia przewodów są solidne i właściwie zaizolowane.
- Do not exceed the specified electrical ratings of 20 Amps and 250 Volts.
- Urządzenie jest przeznaczone wyłącznie do użytku wewnątrz pomieszczeń.
Failure to follow these instructions may result in serious injury, death, or property damage.
Produkt ponadview
The Leviton 5821-W is a commercial specification grade single receptacle outlet. It features a smooth face and is designed for side wiring. The NEMA 6-20R configuration indicates it is a 2-pole, 3-wire grounding receptacle rated for 20 Amps przy 250 woltach.
Rycina 1: Przód view of the Leviton 5821-W Single Receptacle Outlet, showing the NEMA 6-20R configuration.
Rysunek 2: Strona view of the Leviton 5821-W Single Receptacle Outlet, highlighting the side wire terminals.
Rysunek 3: Tył view of the Leviton 5821-W Single Receptacle Outlet, showing the robust construction and wiring access points.
Konfiguracja i instalacja
Wymagane narzędzia: Screwdriver (Phillips and flathead), Wire Strippers, Electrical Tape, VoltagTester.
- Wyłącz zasilanie: Znajdź wyłącznik lub bezpiecznik sterujący gniazdkiem, które wymieniasz lub instalujesz. Wyłącz go. Sprawdź, czy zasilanie jest wyłączone, używając przełącznika głośności.tagtester.
- Remove Old Receptacle (if applicable): Unscrew the wall plate and then the mounting screws holding the old receptacle in the electrical box. Carefully pull the old receptacle out of the box. Disconnect the wires, noting which wire was connected to which terminal.
- Przygotuj przewody: Strip approximately 1/2 inch (12.7 mm) of insulation from the ends of the circuit wires. Ensure the wire ends are clean and straight.
- Podłącz przewody: The Leviton 5821-W is a side-wire only device.
- Połącz CZARNY or CZERWONY (hot) wire to the MOSIĄDZ terminal screw.
- Połącz BIAŁY (neutral) wire to the SREBRNY terminal screw.
- Połącz ZIELONY or bare copper (ground) wire to the ZIELONY terminal screw.
- Gniazdo montażowe: Carefully fold the wires into the electrical box, leaving enough room for the receptacle. Insert the receptacle into the box and secure it with the mounting screws.
- Zainstaluj płytę ścienną: Attach the wall plate over the receptacle and secure it with the provided screw(s).
- Przywróć zasilanie: Włącz ponownie zasilanie za pomocą wyłącznika obwodu lub skrzynki bezpiecznikowej.
- Test: Verify the receptacle is functioning correctly with a suitable device.
Instrukcja obsługi
The Leviton 5821-W Single Receptacle Outlet operates by providing a 20 Amp, 250 Volt power connection for compatible NEMA 6-20P plugs. Simply insert the plug of your electrical device into the receptacle. Ensure the plug is fully inserted for a secure connection.
This receptacle is designed for continuous duty within its specified ratings. It does not feature any user-operable controls or indicators.
Konserwacja
The Leviton 5821-W receptacle requires minimal maintenance. Regular inspection and cleaning are recommended to ensure optimal performance and safety.
- Czyszczenie: To clean the surface of the receptacle, first turn off power at the circuit breaker. Use a soft, damp cloth with a mild detergent. Do not use abrasive cleaners or solvents. Ensure the surface is completely dry before restoring power.
- Kontrola: Periodically inspect the receptacle for any signs of damage, such as cracks, discoloration, or loose connections. If any damage is observed, turn off power immediately and have the receptacle inspected and replaced by a qualified electrician.
- Szczelność: Over time, wire connections can loosen. If you suspect a loose connection (e.g., flickering power, heat from the outlet), turn off power and have a qualified electrician check and tighten all terminal screws.
Rozwiązywanie problemów
If you experience issues with your Leviton 5821-W receptacle, refer to the following common troubleshooting steps. Always ensure power is OFF before performing any inspection or repair.
| Problem | Możliwa przyczyna | Rozwiązanie |
|---|---|---|
| Brak zasilania w gniazdku. | Circuit breaker tripped or fuse blown. Loose wiring connection. Faulty receptacle. | Check and reset the circuit breaker or replace the fuse. Turn off power and check wire connections; tighten if loose. If problem persists, replace the receptacle. |
| Plug does not fit or is loose. | Incorrect plug type (not NEMA 6-20P). Worn receptacle contacts. | Ensure the device plug is NEMA 6-20P. If contacts are worn, replace the receptacle. |
| Receptacle feels warm. | Overload. Loose wiring connection. | Reduce the load on the circuit. Turn off power and check wire connections; tighten if loose. If warmth persists, consult a qualified electrician. |
If troubleshooting steps do not resolve the issue, contact a qualified electrician for assistance.
Specyfikacje
| Funkcja | Szczegół |
|---|---|
| Marka | Lewiton |
| Model | 5821-W |
| Typ | Pojedyncze gniazdko |
| Stopień | Commercial Specification Grade |
| Ampwymazać | 20 Amps |
| Tomtage | 250 wolty |
| Konfiguracja NEMA | 6-20R |
| Słupy/przewody | Uziemienie 2-biegunowe, 3-żyłowe |
| Metoda okablowania | Side Wire Only |
| Tworzywo | Nylon |
| Kolor | Biały |
| Wymiary produktu | 12.5"L x 8"W (Note: This dimension seems unusually large for an outlet. It might refer to packaging or a different measurement. Actual device dimensions are typically smaller.) |
| Certyfikaty | UL Listed 498, CSA Certified, NOM Certified, Meets NEMA WD-1 and WD-6, ANSI Standards |
| UPC | 078477790281 |
Gwarancja i wsparcie
Gwarancja: This Leviton product is backed by a limited 10-year warranty on parts. For specific terms and conditions, please refer to the warranty documentation included with your purchase or visit the official Leviton webstrona.
Obsługa klienta: For technical assistance, product inquiries, or warranty claims, please contact Leviton customer support through their official website or the contact information provided in your product packaging. Always provide the model number (5821-W) when seeking support.
You can visit the official Leviton store for more information: Sklep Leviton